USCG issues Safety Alert on Pilot Ladder handhold stanchion arrangements

The safety alert follows an investigation involving a fall from a pilot ladder where the handhold stanchions terminated without being rigidly secured to the deck. This resulted in a gap on the handhold stanchion in an area where an embarking pilot could reach up to pull themselves onto the vessel.

The safety alert states that the arrangement on the vessel in question appeared to have been a modification. It is likely that this was done to enable the spreaders on the pilot ladder to pass under the handhold stanchions,  rather than having to run them over the vessel’s railing when deploying or retrieving the pilot ladder.

SOLAS is clarified by IMO Resolution A.1045 (27) to indicate that each handhold in a gateway arrangement should be rigidly secured to the ship’s structure at or near its base:

The Coast Guard strongly recommends that flag State administrations, classification societies, port State control inspectors, and shipboard personnel:

• Ensure familiarity with applicable requirements pertaining to handholds in gateway embarkation arrangements aboard merchant vessels.
• Visually examine handholds in gateway embarkation arrangements for gaps, specifically at the lower terminations.
• Initiate rectification and issue outstanding conditions to meet regulatory intent for any non-conformities discovered.

Vessels calling at US ports should consider the increased possibility that pilot boarding arrangements may be an area that USCG inspectors focus on during PSC inspections.

For further guidance:

• ICS document: Shipping Industry Guidance on Pilot Transfer Arrangements.
• North ‘Quickfacts’ on pilot ladders.
• IMO Resolution A.1045(27) PILOT TRANSFER ARRANGEMENTS.
• Pilots Take Action Against Non-Compliant Boarding Arrangements

The full safety alert can be read here.